How many times have you had someone say to you their 4WD is only getting 500km out of a tank of fuel? What does that mean to you? How big is the fuel tank, and how far are they running it down? What size engine, tyres, and driving habits do they have? Were they doing 90km/h on flat ground, or sitting on 110km/h up and down hills on cruise control? Fuel economy varies wildly depending on where and how you are driving. You can easily monitor your fuel economy every time you fill up; it takes a few seconds to do!

It is very useful to keep an eye on your fuel economy, as you can plan your fuel stops for future 4WD trips, ensure the vehicle is running as it should and understand how different conditions can change your fuel consumption.


4WD fuel economy

No matter what you pay for fuel, its worth knowing your economy

Is your speedometer correct?

The first thing you should really do is ensure that your speedometer is correct. If you have changed tyre sizes, there’s a good chance it won’t be! If your speedo is not correct, your trip meter won’t be either. You can do this one of two ways; drive along with a GPS at 100km on the speedometer and see what the GPS says (less accurate), or drive 100km on the vehicles trip meter, and see how many km you have done according to the GPS.

There will be a difference if you have changed tyre sizes as the bigger the tyre the less revolutions per kilometer it will do, compared to the original tyres on the vehicle. This puts your speedo out. For people that have gone from 265’s to 285’s (or 31’s to 33’s) your speedo is usually out by 5 – 10%.

Fitting bigger tyres to your 4WD

usually results in worse fuel economy. How much, is dependant on many factors; see the link for more information.

For our 80 series, 100km on the trip meter is actually about 105km – its out by 5% due to the larger diameter tyres.

Once you understand the difference in your speedo, you can work your fuel economy out every time you fill up. Simply remember to add 5% of your trip meter to the reading, and you can get an accurate economy figure.


Speedometer correction

Bigger tyres put your speedometer out

Working out your fuel economy

The easiest way to work out your fuel economy is done when you fill up at a service station. Fill the tank all the way, until the nozzle clicks. Once you’ve paid, get back in your car (move out the way!) and reset the trip meter. From there, drive your vehicle around until you want to fill it up again.

When you put more fuel in, fill it up again until it clicks, and take note of the number of km you have done on your trip meter.

If you haven’t changed your tyre size, you can skip the trip meter correction step. If you have changed your tyre size, remember to factor in the extra km you have actually travelled due to the tyres.

An example

Lets say we put 98.5L of diesel in our 80 series, and we’ve done 653.8km on the trip meter. We know the trip meter is out by 5%, so we multiply 653.8km by 1.05.

This gives us a correct reading (after factoring in the tyres) of 686.49km.

From there, simply divide the amount of fuel you’ve used (98.5L) by the number of km (686.49). The result needs to be multiplied by 100. This gives you an accurate fuel economy reading of 14.35 litres of diesel per 100km.

KM done on trip meter when filling up = 653.8

653.8 x 1.05 = 686.49km done on 98.5L of diesel.

(98.5/686.49) x 100 = 14.35 litres of diesel per 100km.


A 4WD GPS

We use our GPS to double check kilometres travelled

Using an app

You can use a number of different apps which work out your fuel economy and record it for you (Fuelly, Road Trip etc), but remember these won’t work out your tyre diameter changes, which makes big difference.

Don’t rely on your cars computer to tell you

A lot of modern 4WD’s will tell you the average fuel consumption, and estimate the number of km’s you have left in the tank. This is handy, but not always very accurate. This is especially the case if you have changed your tyre sizes, as the vehicles computer works off a certain number of revolutions of the tyre per kilometer, and you’ve just changed that by fitting bigger tyres to your 4WD.

When will I use more fuel in my 4WD?

4WD’s are not small, or light weight, and they do tend to use their fair bit of fuel. However, you will use a lot more fuel by doing the following

Driving in soft sand


Fuel consumption on sand

Sand driving will chew the fuel

Soft sand is usually where you will go through the most fuel. This is where your vehicle is working the hardest to maintain momentum, and as a result uses more fuel. For petrol vehicles, you can use up to 50% more fuel, and diesels usually around 30% more (but this does depend on your vehicle!)

Driving at 110km/h

The difference between doing 90km/h and 100km/h is huge on your fuel economy (usually a litre or 2 per hundred km). Going from 100km/h to 110km/h is substantially more. Often this is in the realms of 1 – 2 litres per 100km too; if you have the time you can save a huge amount of money by slowing down!

Accelerating rapidly

Your driving habits play a big role in your fuel economy too. If you are accelerating quickly, braking hard and changing throttle positions rapidly you will use more fuel!

Running under inflated tyres


22R dual cab hilux

Under unflated tyres causes excessive fuel consumption

Your tyre pressures are critical to good fuel economy. The more you inflate them the better your economy will be. However, if you run them too hard you will have very little traction and risk having an accident. For most 4WD’s tyre pressures in between 30 and 45PSI is appropriate.

Towing a trailer

The moment you tow something, your vehicle has to work harder. Sometimes this is made worse by wind drag, but in majority of cases its just the fact that you are dragging a weight behind your vehicle.

Roof racks, bigger tyres, different tread patterns and more weight


Big Caravan

This is going to hurt your fuel economy!

Anything that makes your vehicle work harder is going to make your fuel economy worse. by adding things to the vehicle that decrease its aerodynamics (like bar work, roof racks etc) your engine has to work harder to push the vehicle along.

If you change to a more aggressive tyre pattern, the airflow around the tyre is disrupted, and you will notice a higher consumption.

The same goes for adding more weight to your vehicle; if you put a 50kg backpack on yourself you will use a lot more energy to move around too!

Bigger tyres will make your 4WD use more fuel, as it has to work harder to turn the tyres. Even if your RPM drops at a given speed, your 4WD still has to work harder!

Sensors and other electrical/mechanical issues

For many modern vehicles, having a sensor (like the MAF) slightly dirty will send your fuel economy through the roof. These control the way the engine behaves, and if they aren’t in pristine condition you can expect poor fuel economy. The same goes for Exhaust gas recirculation systems, which tend to cake your engine up with build up. Fuel and air filters are another common cause of high fuel consumption too.

There’s a range of other things that will affect your fuel economy, but if you take the time to work it out every time you fill up, you will get an idea for yourself!

Our 80 series 1HDT fuel economy

Our turbo diesel 80 series is not the most fuel efficient 4WD on the market. It’s nearly 26 years old, and has done 374,000km. We knew this when we bought it, and have been extremely happy with it.

For general driving around town and taking it easy our 80 gets around 14.5 – 15L/100km.

If we are travelling at the speed limit on longer trips with some gear in the back it seems to go up to around 16L/100km, and on our 9000km trip to the Kimberley we averaged 16.7L/100km. This included a fair bit of 4WDing, sitting at 110km/h where allowed and not really taking it too easy.

For a vehicle that weighs quite a bit, has bigger tyres, almost every accessory under the sun and is 26 years old, we are extremely happy with it.


4WDing Australia 80 series

Filling up with fuel in our 80 Series

What fuel economy do you get?

What sort of fuel economy you get in your 4WD? Let us know a bit about it, and how often you check your fuel economy!

Facebook Comments